Springs, cables & track
Garage door spring repair in Sidney
One loud bang and the door turned into 150 pounds of dead weight. That's a broken spring - the most common repair we make, and the one you should not attempt yourself.
What happened
The bang, explained
Your door doesn't lift itself - the opener just steers. The real muscle is a torsion spring (the fat coil on the bar above the door) or a pair of extension springs (the long ones beside the tracks), wound to balance the door's exact weight. Steel fatigues one cycle at a time until, one cold Sidney morning, it lets go all at once. That's the gunshot sound half our callers describe.
After it breaks, the opener strains against the full weight of the door. Best case it refuses to lift. Worst case it hauls the door halfway up, the cables jump their drums, and a spring job becomes a spring-cable-and-track job. If the spring is broken, stop using the opener.
What we do
Matched, not guessed
Springs aren't one-size-fits-all - they're specified by wire size, inside diameter, and length against your door's measured weight. We carry the common Shelby County sizes on the truck, measure rather than assume, and set the balance so the door floats at half-open the way it should.
- Torsion & extension spring replacement, matched to the door
- Both-spring replacement recommended on double doors - one trip, one bill
- Frayed cable and drum replacement while the tension is already off
- Off-track and bent-track correction, rollers and hinges checked
- High-cycle spring upgrade if you want the 20,000-cycle version
Straight answers
Spring questions we hear every week
How much does it usually cost to replace a garage door spring?
In Shelby County, plan on $150 to $350 per spring including labor. Double doors usually run two springs, and if one broke from age we recommend replacing both in the same visit - the second one is living on the same clock, and doing both at once saves you a second service call.
Can I fix a garage door spring myself?
We won’t tell you it’s illegal - we’ll tell you it’s the one garage door job that sends people to the emergency room. A wound torsion spring stores the full lifting force of a 150-plus pound door. Without winding bars, the right stand, and practice, the failure mode is violent. This is the repair to hire out.
How do I know it’s the spring and not the opener?
Pull the red release cord and try lifting the door by hand. A healthy door lifts with one hand and stays put halfway. If it feels like dead weight, the spring is gone - and running the opener against it will burn the opener out too.
How long do garage door springs last?
Springs are rated in cycles - one open-and-close is a cycle. Standard springs are 10,000 cycles, which is 7 to 10 years for most families. Ohio winters shorten that: cold steel is brittle steel, which is why springs love to snap on the first hard freeze. High-cycle springs cost a little more and roughly double the life.
Ranges for every spring job are published on our cost page - and your exact number always comes in writing before we start.
Heard the bang? Don't touch the opener - call.
We'll confirm it's the spring over the phone and tell you what's safe to do until we arrive.
Written quotes
Every job priced in writing before it starts
Send us what the door is doing and we’ll come back with the likely cause and a written quote - parts, labor, the whole number. Prefer the phone? (937) 507-8225.
- Written quote before any work starts - every time
- Itemized invoice: parts, labor, nothing buried
- Cards welcome - never a cash-only surprise